Page 1 of 3

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB160  
    Pre-opening
X Original Inspection
    Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  CULVER'S OF BOURBONNAIS Address  983 N CONVENT ST
Owner or Operator   MAIER, BOBBY City   BOURBONNAIS Zip Code   60914
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
  
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
  
5
 Source, Wholesome, No Spoilage
19
  
2
 Wash, rinse after: clean, proper temperature
2
  
1
 Original Container, Properly Labeled
*20
X
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
X
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
X
1
 Wiping cloths: clean, use restricted
22
  
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
  
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
 
1
 Non-food contact surfaces of equipment and utensils clean
5
 
1
 Thermometers provided and conspicuous
37
  
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
 
2
 Potentially hazardous food properly thawed
24
  
1
 Storage, handling of clean equipment utensils
*7
  
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
  
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
  
1
 Lighting provided as required - Fixtures shielded
8
  
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
X
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
X
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
  
1
 Installed, maintained
*41
  
5
 Toxic items properly stored, labeled and used
*12
  
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
  
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
  
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
  
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
 
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
X
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes X No     Registered for class    
 
GARBAGE AND REFUSE DIPSOSAL
17
  
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
X
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   Quat 200-400 ppm                   Dishwasher Temperature   120-140 °F or label
Food Temperatures:   cheese 42, beef gravy 138, chicken 135, mashed potato 145, BBQ pork 148, chili 147, Pot roast 153, corn beef 34, turkey 37, milk 30, Fried chicken -12, chicken noodle 159, chicken & dumpling 155
 
General Comments
HACCP: Discussed proper santizer level. 
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  12/17/2009 Time In  1:30 PM Time Out  3:15 PM Sanitation Score  84 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  93  
 
Page 2 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB160  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  CULVER'S OF BOURBONNAIS Address  983 N CONVENT ST
Owner or Operator   MAIER, BOBBY City   BOURBONNAIS Zip Code   60914
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
*3  Observed the following potentially hazardous foods to be held at improper temperatures. 1. Raw hamburger was stacked too high and was found at 52F. 2. Turkey was found at 60F, it was also stacked too high. 3. Ham was found at 55F on the prep line. All meats were brought down to pan level, and all extra meat was stored in walk-in cooler at 41F or below. Provide for all cold potentially hazardous foods to be held at 41°F or below at all times except during necessary periods of preparation. 750.120 Immediate/Onsite
*20  Observed the sanitizer solution to be too weak at the following location(s). Sanitizer bucket was too weak in bucket at drive thru. Provide for the sanitizer solution to be mixed to the appropriate level for the type of sanitizer being used. Manager adjusted level of sanitizer. 750.830 Immediate/Onsite
9  Observed food service employees to be handling ready-to-eat foods without minimizing direct hand contact with the food product. Cups were being used in the peacans, cashews, and flour located in the dry storage room. Food employees shall avoid direct contact with ready-to-eat food whenever possible and, to the extent possible, shall handle ready-to-eat food only with suitable utensils such as a deli tissue, spatulas, tongs, or single-use gloves. 750.280 Next Inspection
10  Observed the following utensil(s) to be improperly stored. 1. Food scoop handle was found in the flour. 2. Food scoop handle was found in the cole slaw. Provide for all utensils to be stored in one of the following manners: 1) Clean and dry 2) In the food product with the handle up and out of the food product 3) In a dipper well, using potable water 4) Malt collars and frozen dessert utensils either clean and dry or ina dipper well. 750.280 Next Inspection
15  Observed the following improper non-food contact surfaces. Seal gaskets are torn at the bottom of freezer doors on prep line. Provide for all food contact surfaces to be smooth, easily cleanable, non-absorbant, corrosive resistant, and light colored. 750.690 Next Inspection
21  Observed the following wiping cloth(s) to be improperly stored: Wiping cloths were soiled and stored at prep tables on cooks line. Provide for all wiping cloths to be stored completely submerged in an approved sanitizer solution while not being used. 750.830 Next Inspection
33  Observed trash can on prep line was full. Empty trash can. Observed dumpster lids were open. Keep shut at all times. 750.1150 Next Inspection
     
     
     
     
     
     
     
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  12/17/2009 Time In  1:30 PM Time Out  3:15 PM Sanitation Score  84 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  93  
 
Page 3 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB160  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  CULVER'S OF BOURBONNAIS Address  983 N CONVENT ST
Owner or Operator   MAIER, BOBBY City   BOURBONNAIS Zip Code   60914
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
     
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  12/17/2009 Time In  1:30 PM Time Out  3:15 PM Sanitation Score  84 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  93